Product ID:S03720 FLAT WHITE, TOUGH COAT GENERAL (SUP DAT)
MSDS Date:09/01/1996
FSC:8010
NIIN:00N084026
MSDS Number: CGRZX

SHERWIN-WILLIAMS CO

31500 SOLON RD
SOLON, OH 44139
US

Emergency Phone: 216-566-2917

Info Phone: 800-777-2966

Cage: DO642

SHERWIN-WILLIAMS DIVERSIFIED BRANDS, INC.

BEDFORD HEIGHTS, OH 44146 US

Telephone: 216-292-7400 OR 216-595-8634

Cage: 09800

760.0

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 14%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT

760.0

CAS: 106-97-8

RTECS: EJ4200000

Fraction By Weight: 13%

OSHA PEL 800 PPM

ACGIH TLV: 800 PPM

7.1

CAS: 100-41-4

RTECS: DA0700000

Fraction By Weight: 4%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM/125 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

5.9

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 21%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM/150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

180.0

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 25%

OSHA PEL 1000 PPM

ACGIH TLV: 750 PPM/1000 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 6.5%

OSHA PEL 20 MPPCF

ACGIH TLV: 2 MG/M3 RDUST

CALCIUM CARBONATE

CAS: 471-34-1

RTECS: FF9335000

Fraction By Weight: 1.2%

OSHA PEL 15.5 MG/M3 (MFR)

ACGIH TLV: 10 MG/M3 (MFR)

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 5.9%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

51.6; VOC

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

CONSULT NFPA CODE. USE APPRVD BONDING &

RTECS: 9999999ZZ

INCIN/EXPOSE TO TEMP >120F. HEAT FROM SUNLIGHT,

RTECS: 9999999ZZ

CONTR TO BURST. DO NOT TAKE INTERNALLY. KEEP OUT OF

RTECS: 9999999ZZ

& INHALING CONTENTS CAN BE HARMFUL/FATAL. THIS

RTECS: 9999999ZZ

PARTICULATES WHICH MAY BE PRESENT AT HAZARDOUS

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSS DEATH. SIGNS & SYMPS OF OVEREXP:HDCH, DIZZ, NAUS & LOSS OF
COORD ARE SIGNS OF EXCESS EXPOS TO VAPS/SPRAY MISTS. REDNESS &
ITCH/BURNING SENSATION MAY INDICATE EYE/EXCESS SKIN EXPOS.
CHRONIC:PRLNG (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:OVEREXP TO SOLVS MAY CAUSE ADVERSE
EFTS TO LIVER, URINARY, BLOOD-FORM, CARDIOVASCULAR & REPRO SYS.
RATS EXPOSED TO TITANIUM DIOXIDE DUST AT 250 MG/M3 DEVELOPED LUNG
CANCER, HOWEVER, SUCH EXPO S LEVELS ARE NOT ATTAINABLE IN
WORKPLACE. RPTS HAVE ASSOC RPTD & PRLNG OVEREXP TO SOLVS W/PERM
BRAIN & NERV SYS DMG.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.

First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
KEEP WARM & QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY W/SOAP &
WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. EYES:
FLUSH W/L ARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET MED
ATTN. INGEST: NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. DO NOT INDUCE VOMITING. GIVE SEVERAL GLASSES OF WATER. SEEK
MED ATTN.

Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:0.7%
Upper Limits:12.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZ ARE
PREF. WATER MAY BE USED TO COOL CLSD (SUP DAT)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPKS &
OPEN FLAME. CLSD CONTRS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
APPLICATION TO HOT SURFS REQUIRES SPECIAL PREC.(SUP DAT)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP
& SPRAY MIST. AVOID CONT W/SKIN & EYES. CONTENTS EXTREMELY FLAM.
KEEP AWAY FROM HEAT, SPKS & OPEN FLAME.
Other Precautions:VAPS WILL ACCUM READILY & MAY IGNITE EXPLO. DURING
USE & UNTIL ALL VAPS ARE GONE: KEEP AREA VENTILATED; DO NOT SMOKE;
EXTING ALL FLAMES, PILOT LIGHTS & HEATERS; TURN OFF STOVES, ELEC
TOOLS & APPLIANCE S, & ANY OTHER SOURCES OF IGNIT.(ING 10)

Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMS BY VENT, WEAR PROPERLY FITTED ORG VAP/PARTICULATE RESP APPRVD
BY NIOSH FOR PROT. WHEN SANDING/ABRADING DRIED FILM, WEAR DUST/MIST
RESP APPRBD BY NI OSH FOR PROT AGAINST NON-VOLATILES.
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS IS MAINTAINED
BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS (SUP DAT)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
TRADE NAME/PART #: PURPOSE PAINTS. FIRE FIGHT PROC: CONTRS TO PVNT
PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOSED TO EXTREME HEAT.
EXPLO HAZ: DURING EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE H
LTH HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN. VENT:
1910.94, 1910.107, 1910.108.

Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.806
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.

Waste Disposal Methods:WASTE MAY BE HAZ AS DEFINED UNDER RCRA 40 CFR
261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE APPLIC EPA
HAZ WASTE NUMBERS. DO NOT INCINERATE. DEPRESSURIZE CONTAINER.
DISPOSE OF I/A/W FEDERAL, STATE, & LOCAL REGULATIONS REGARDING
POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.